Governed by: Ministry of Industry and Information Technology of the People's Republic of China
Sponsored by: Northwestern Polytechnical University  Chinese Society Aeronautics and Astronautics
Address: Aviation Building,Youyi Campus, Northwestern Polytechnical University
Accelerated effectiveness evaluation method based on quantitative identification of physical characteristics
Affiliation:

Fudan University

Clc Number:

V232. 4;V215. 5

  • Article
  • | |
  • Metrics
  • |
  • Reference [27]
  • | | | |
  • Comments
    Abstract:

    Conducting accelerated test has gradually become an important way for performance analysis and life management of aviation high-performance structures (such as turbine blades). However, the reasonable and effective evaluation of accelerated test results has become a difficult problem restricting the development of accelerated test technology. Therefore, based on the existing physical mechanism methods, by constructing the quantitative relationship between microstructure characteristics and macro performance, this paper proposes an acceleration effectiveness evaluation method based on quantitative identification of micro characteristics, and systematically explains the acceleration damage and failure mechanism of turbine blades. This method uses a variety of advanced detection technologies to perform qualitative analysis and quantitative characterization of fracture morphologies, microstructures and element compositions, and takes the typical characteristics in field service as the comparison benchmark, which overcomes the main shortcomings of the existing physical mechanism methods and makes the evaluation results more accurate and reliable. The method proposed in this paper has important reference significance for improving the accuracy of performance analysis and life prediction of aviation high-performance structures.

    Reference
    [1] 唐学智, 李录平, 黄章俊等, 重型燃气轮机涡轮叶片寿命分析研究进展, 燃气轮机技术 28(3) (2015) 6-13.X. Tang, L Li, Z. Huang, et al, Development of study on Life Prediction for Turbine Blade of Heavy-Duty Gas Turbine, Gas Turbine Technology 28(3) (2015) 6-13.
    [2] 徐可君, 江龙平, 军用航空发动机可靠性和寿命管理, 中国工程科学 (01) 86-92.K. Xu, L Jiang. Reliability and life management of military aeroengine, Strategic Study of CAE (01) 86-92.
    [3] 卢文海, 刘丽玉, 白明远, 发动机燃气涡轮叶片断裂分析, 失效分析与预防 (4) 64-68.W. Lu, L Liu, M. Bai,. Fracture analysis of gas turbine blades of aircraft engine, Failure Analysis and Prevention (4) 64-68.
    [4] C. Cross, Multiaxial testing of gas turbine engine blades, AIAA Journal (2013).
    [5] B. Powell, M. Hawkyard, L. Grabowski, The growth of cracks in Ti–6Al–4V plate under combined high and low cycle fatigue, International Journal of Fatigue 19(93) (1997) 167-176.
    [6] E. Vacchieri, et al, Service-like TMF tests for the validation and assessment of a creep-fatigue life procedure developed for GT blades and vanes, International Journal of Fatigue 99 (2017) 216-224.
    [7] 闫晓军, 聂景旭, 定向结晶涡轮叶片蠕变/疲劳寿命的试验与分析, 航空动力学报 (06) 27-33.X. Yan, J. Nie. New experimental approach in determining creep/fatigue life of directionally solidified alloy turbine blade, Journal of Aerospace Power (06) 27-33.
    [8] 王荣桥, 荆甫雷, 胡殿印, 单晶涡轮叶片热机械疲劳试验技术, 航空动力学报 (02) 17-23.R. Wang, F. Jing, D. Hu. Experimental setup for testing thermal-mechanical fatigue of single crystal turbine blades, Journal of Aerospace Power (02) 17-23.
    [9] 马楠楠, 陶春虎, 何玉怀等, 航空发动机叶片多轴疲劳试验研究进展, 航空材料学报 32(6) (2012) 44-49.N. Ma, C. Tao, Y. He, Research progress of multiaxial fatigue test methods on blades of aviation engine, Journal of Aeronautical Materials 32(6) (2012) 44-49.
    [10] 胡晓安, 石多奇, 杨晓光等, TMF本构和寿命模型:从光棒到涡轮叶片, 航空学报 40(3) (2019) 494-511.X. Hu, D. Shi, X. Yang, et al, TMF constitutive and life modelling: from smooth specimen to turbine blade, Acta Aeronautica Astronautica Sinica 40(3) (2019) 494-511.
    [11] 张静静, He-Ne激光器加速寿命试验研究, 西安电子科技大学,2008.J. Zhang, Study on accelerated life test of He-Ne laser, Xidian University 2008.
    [12] 刘俊俊, 电连接器贮存可靠性加速寿命试验的研究, 浙江理工大学, 2010.J. Liu, Research on accelerated life test of electrical connecters storage reliability, Zhejiang Sci-Tech University 2010.
    [13] 王浩伟, 滕克难, 盖炳良, 基于加速因子不变原则的加速退化数据分析方法, 电子学报 46(3) (2018) 739-747.H. Wang, K. Teng, B. Gai, The Method of analyzing accelerated degradation data Based on acceleration factor constant principle, Acta Electronica Sinica 46(3) (2018) 739-747.
    [14] 周源泉, 翁朝曦, 对数正态分布环境因子的统计推断, 系统工程与电子技术 (10) 73-81.Y. Zhou, C. Weng, Statistical inferences of environmental factors for the lognormal distribution, System Engineering and Electronics (10) 73-81.
    [15] 郭春生, 万宁, 马卫东等, 恒定温度应力加速实验失效机理一致性快速判别方法, 物理学报 62(6) (2013) 470-474.C. Guo, N. Wan, W. Ma, et al, Rapid identification of the consistency of failure mechanism for constant temperature stress accelerated testing, Acta Physica Sinica 62(6) (2013) 470-474.
    [16] 潘晓茜, 康锐, 基于灰色预测的加速试验机理一致性判定方法, 北京航空航天大学学报 (06) 80-84+90.X. Pan, R. Kang, Identification method of failure mechanism consistency for accelerated testing on grey forecasting, Journal of Beijing University of Aeronautics and Astronautics (06) 80-84+90.
    [17] E. Dalton, et al, Accelerated temperature cycling induced strain and failure behaviour for BGA assemblies of third generation high Ag content Pb-free solder alloys, Materials Design 154 (2018) 184-191.
    [18] X. Lu, M. Ding, C. Zhang, et al, Investigation on microstructure evolution and failure mechanism of boron doped diamond coated titanium electrode during accelerated life test, Thin Solid Films 660(08) (2018) 306-313.
    [19] 郑鑫, 铸铝合金的高低周复合疲劳裂纹扩展和寿命研究, 南京航空航天大学, 2012.X. Zheng, Study on fatigue crack propagation and fatigue life for cast aluminum alloys under high-cycle low-cycle interaction loading, Nanjing University of Aeronautics and Astronautics 2012.
    [20] W. Li, H. Cui, W. Chen, et al, Very High Cycle Fatigue of Cast Aluminum Alloys under Variable Humidity Levels, Sae International Journal of Materials Manufacturing 8(2) (2015) 0556-0562.
    [21] X. Zheng, et al, Modeling of fatigue damage under superimposed high-cycle and low-cycle fatigue loading for a cast aluminum alloy, Materials Science Engineering A 560 (2013) 792-801.
    [22] L. Han, Y. Wang, et al, Competitive cracking behavior and microscopic mechanism of Ni-based superalloy blade respecting accelerated CCF failure, International Journal of Fatigue 150(618) (2021) 106306.
    [23] 冯强, 童锦艳, 郑运荣等, 燃气涡轮叶片的服役损伤与修复, 中国材料进展 31(12) (2012) 21-34.Q. Feng, J. Tong, Y. Zheng, et al, Service induced degradation and rejuvenation of gas turbine blades, Materials China 31(12) (2012) 21-34.
    [24] X. Qin, J. Guo, C. Yuan, et al, Long-term thermal exposure responses of the microstructure and properties of a cast Ni-base superalloy, Materials Science Engineering A 543 (2012) 121-128.
    [25] J. Wang, L. Zhou, et al, Primary MC decomposition and its effects on the rupture behaviors in hot-corrosion resistant Ni-based superalloy K444, Materials Science Engineering A 553(36) (2012) 14-21.
    [26] C. Schweizer, T. Seifert, B. Nieweg, a.l. et, Mechanisms and modelling of fatigue crack growth under combined low and high cycle fatigue loading, International Journal of Fatigue 33(2) (2011) 194-202.
    [27] H. Abdesselam, J. Crepin, et al, On the crystallographic, stage I-like, character of fine granular area formation in internal fish-eye fatigue cracks, International Journal of Fatigue 106 (2018) 132-142.
    Related
    Cited by
    Comments
    Comments
    分享到微博
    Submit
Get Citation

Lei Han, Shanghong Liao, Shengjie Yu, Chengwei Fei. Accelerated effectiveness evaluation method based on quantitative identification of physical characteristics[J]. Advances in Aeronautical Science and Engineering,2021,12(5):50-58,74

Copy
Share
Article Metrics
  • Abstract:954
  • PDF: 1393
  • HTML: 0
  • Cited by: 0
History
  • Received:June 28,2021
  • Revised:September 16,2021
  • Adopted:September 17,2021
  • Online: October 26,2021
Article QR Code